| | Author | Message |
---|
jai KCOC Partner Club
Posts : 644 Age : 36 Location : jipun
| Subject: Blowoff valve Tue 03 Nov 2009, 00:38 | |
| Definitions A compressor bypass valve (CBV), also known as a compressor relief valve or diverter valve, is a vacuum-actuated valve designed to release pressure in the intake system of a turbocharged car when the throttle is lifted or closed. This air pressure is re-circulated back into the non-pressurized end of the intake (before the turbo) but after the mass airflow sensor. A blowoff valve, (BOV, sometimes hooter valve, not to be confused with a dump valve) performs the same task but releases the air into the atmosphere instead of recirculating it. The blowoff action produces a range of distinctive hissing sounds, depending on the exit design. Some blowoff valves are sold with a trumpet shaped exit that intentionally amplifies the sound. The TurboXS model RFL blow off valve is well known among tuners for this kind of design and some turbocharged vehicle owners may purchase a blowoff valve solely for the auditory effect even when the function is not required by normal engine operation. Motor sports governed by the FIA have made it illegal to vent unmuffled blowoff valves to the atmosphere. In the United States, Australia and parts of Europe cars featuring unmuffled blowoff valves are illegal for street use.[citation needed] Blowoff valves are used to prevent compressor surge, a phenomenon that readily occurs when lifting off the throttle of an unvented, turbocharged engine. When the throttle plate on a turbocharged engine closes, the high pressure air in the intake system is trapped by the throttle and a pressure wave is forced back into the compressor. The compressor wheel slows rapidly and may even stall, and the driver will notice a fluttering air sound. The rapid slowing or stalling stresses the turbo and imparts severe turbo lag if the driver accelerates immediately after the surge event. |
| | | jai KCOC Partner Club
Posts : 644 Age : 36 Location : jipun
| Subject: Re: Blowoff valve Tue 03 Nov 2009, 00:38 | |
| Disadvantages In the case where a mass airflow sensor is used and must be located prior to the blowoff valve, the engine control unit (ECU) will meter out excess fuel because the atmospherically vented air is not subtracted from the intake charge measurements. The engine then briefly operates with a fuel-rich mixture after each valve actuation. The rich mixing can lead to hesitation or even stalling of the engine when the throttle is closed, a situation that worsens with higher boost pressures. Occasional events of this type may be only a nuisance, but frequent events can eventually foul the spark plugs and destroy the catalytic converter, as the inefficiently combusted fuel produces soot (excess carbon) and unburned fuel in the exhaust flow can produce soot in the converter and drive the converter beyond its normal operating temperature range. One way to mitigate the problem is to reduce the boost pressure, which reduces the required venting volume and yields less charge overcalculation by the ECU. The air can also be recirculated back into the intake, a typical stock setup for cars with an upstream MAF sensor. The situation can also be corrected by switching the fuel metering system over to a manifold absolute pressure sensor, a conversion that usually requires a compatible aftermarket ECU or piggy-back fuel controller. The MAP sensor monitors the absolute pressure in the manifold at all times and will correctly detect the change that occurs when the valve vents, allowing the ECU to reduce fuel metering accordingly. |
| | | jai KCOC Partner Club
Posts : 644 Age : 36 Location : jipun
| Subject: Re: Blowoff valve Tue 03 Nov 2009, 00:39 | |
| Operation A blow-off-valve is connected by a vacuum hose to the intake manifold after the throttle plate. When the throttle is closed, manifold vacuum without pressure develops in the intake manifold after the throttle plate and "sucks" the blow off valve open. The excess pressure from the turbocharger is vented into the atmosphere or recirculated into the intake upstream of the compressor inlet. |
| | | jai KCOC Partner Club
Posts : 644 Age : 36 Location : jipun
| Subject: Re: Blowoff valve Tue 03 Nov 2009, 00:40 | |
| to the wastegate and bov. |
| | | adam garage KCOC Senior
Posts : 72 Age : 40 Location : kingfisher,kk
| Subject: Re: Blowoff valve Wed 18 Nov 2009, 00:35 | |
| wow..siap gambar.................................................. |
| | | jai KCOC Partner Club
Posts : 644 Age : 36 Location : jipun
| Subject: Re: Blowoff valve Wed 18 Nov 2009, 05:26 | |
| untuk lg senang paham bha..xbgitu?huhu |
| | | arul KCOC Junior
Posts : 3 Age : 41 Location : labuan & sabah
| Subject: Re: Blowoff valve Tue 12 Jan 2010, 23:04 | |
| klu bahasa melayu lg paham hehehe.... |
| | | matnoor KCOC Moderator
Posts : 284 Age : 37 Location : Labuan & kk
| Subject: Re: Blowoff valve Wed 13 Jan 2010, 01:02 | |
| nice nice nice..phm la jua skit..hehehe..klu x mau pakai pun bole..tp, pasti kan tebo yg di gunakan pada asal nya tdk pakai blowoff..mcm tebo diesel tdo4, starlet ct-9 kah..huhu ni ada otai ckp hari tu..aku copy dari mulut dan paste p sini.. |
| | | Emanrina KCOC Administrator
Posts : 2233 Age : 41 Location : Sabah-Labuan
| Subject: Re: Blowoff valve Wed 13 Jan 2010, 08:47 | |
| baik cerita tubo suda kamu...kekekeke...kansil ku nda lg mengechingggg bah...wakakakakaka |
| | | matnoor KCOC Moderator
Posts : 284 Age : 37 Location : Labuan & kk
| Subject: Re: Blowoff valve Wed 13 Jan 2010, 11:01 | |
| n/a pun best bah man..hehehe..kasi tggi ja compres bru lah mnginjat.. |
| | | Emanrina KCOC Administrator
Posts : 2233 Age : 41 Location : Sabah-Labuan
| Subject: Re: Blowoff valve Wed 13 Jan 2010, 12:20 | |
| 850cc..wkakakaka...masuk piston 660...masuk adjustable & highcam.. |
| | | matnoor KCOC Moderator
Posts : 284 Age : 37 Location : Labuan & kk
| Subject: Re: Blowoff valve Wed 13 Jan 2010, 14:05 | |
| naaa ko kuasa itu..hehehe |
| | | Emanrina KCOC Administrator
Posts : 2233 Age : 41 Location : Sabah-Labuan
| Subject: Re: Blowoff valve Wed 13 Jan 2010, 16:45 | |
| kuasa tggl diblakang la..abis kana pancit olih tubo...mataiii..wakakakakaka |
| | | jai KCOC Partner Club
Posts : 644 Age : 36 Location : jipun
| Subject: Re: Blowoff valve Thu 14 Jan 2010, 05:31 | |
| - emanrina_kcar wrote:
- 850cc..wkakakaka...masuk piston 660...masuk adjustable & highcam..
kuat jua 2..huhu |
| | | Emanrina KCOC Administrator
Posts : 2233 Age : 41 Location : Sabah-Labuan
| Subject: Re: Blowoff valve Thu 14 Jan 2010, 21:25 | |
| lidut sja bah tu jai...hehehe |
| | | Sponsored content
| Subject: Re: Blowoff valve | |
| |
| | | |
Page 1 of 1 | |
| Permissions in this forum: | You cannot reply to topics in this forum
| |
| |
| Latest topics | » logo dan sticker Kancil Kelisa Club (KKC)Sun 03 May 2015, 10:25 by Gr Vishnu » aku tanya apa khabar, semuaaaaa...Mon 16 Feb 2015, 13:49 by bucu» Salam PerkenalanMon 26 Jan 2015, 20:22 by moderno L6 » bah kasi list cni...Wed 09 Apr 2014, 18:16 by JhaimL2s » mukadimahMon 04 Nov 2013, 12:45 by golibung » Budak baru join..Mon 09 Sep 2013, 21:46 by aimtargetsr2020 » KELISA edict-ed Wed 17 Apr 2013, 09:36 by Yzura » Hello GuysSun 09 Dec 2012, 17:16 by samchee88 » Stiker roadtax KCOC, RM10.00Sat 20 Oct 2012, 10:01 by arinahM » Lampu indicator handbreak & bateri menyala..Mon 17 Sep 2012, 22:20 by Jimi » Salam perkenalan...Mon 17 Sep 2012, 22:18 by Jimi » Salam PerkenalanFri 07 Sep 2012, 02:13 by WakLee » salam perkenalanThu 23 Aug 2012, 11:44 by azrulplayaz » (WTS)HID Slim Ballast Full Set, H1,H3,H4,H7,H8,H11,9005,9006 Tue 10 Jul 2012, 14:41 by a'performance » (WTS) Led for t10,Cabin Led Room BulbFri 29 Jun 2012, 22:34 by a'performance » KCOC Member CardSat 17 Mar 2012, 12:33 by Emanrina» kelisaownerThu 23 Feb 2012, 15:03 by sonic» salam pkenalan..i'm newbeee here...Thu 23 Feb 2012, 15:01 by sonic» mi garage autopart..aksesori & part = update stok baruThu 19 Jan 2012, 01:03 by mi kancil » salam perkenalanMon 26 Dec 2011, 22:13 by syahir09 |
Who is online? | In total there are 5 users online :: 0 Registered, 0 Hidden and 5 Guests None Most users ever online was 172 on Fri 11 Feb 2011, 04:00 |
Chery Promotion Banner |
|
KCOC Garage Banner |
|
Advertisement Banner |
|
KCOC Marchandise |
|
Online Games | Traffic Slam.
_______________
Drag Racer V3.
_______________
Degree V12.
_______________
American Dragrace.
_______________ |
Statistics | We have 395 registered users The newest registered user is Adamsan88
Our users have posted a total of 6797 messages in 441 subjects
|
|